Question 1

Does a 2011 Hyundai iLoad differential have any yellow metal components (brass, bronze) in it?

Accepted Answer

It’s possible – although pretty unlikely - that a modern car still uses bronze bushings somewhere in the differential or drive-axle assembly. The material is likely to be bronze or phosphor-bronze. I’m tipping you’ve performed a differential-oil drain and found a few metallic-looking bits in the bottom of the rain pan. This is never a good thing to find, as it suggests that something is wearing inside the diff and shedding these filings. It’s actually not abnormal for a few tiny fragments to appear in the oil, but if the bottom of the drain pan glitters like you’re panning for gold, then you have a potential problem. Even though the fragments might look yellowish, they could have started out silver (like normal bearing material) but have become discoloured due to time and heat in the environment in which they operate. So, just because they look like bronze or brass, they could be made from any type of bearing material. At which point you need to investigate further.

Question 2

The gearbox in my 2009 Hyundai iLoad clunks going into gear

Accepted Answer

There’s every chance this is caused by a small amount of wear and slack in one of the joints in the driveline. If that’s the case, those joints and couplings need to be checked and the worn one(s) replaced, as continuing to drive as it is could see the driveline fail spectacularly at speed.

The reason you feel the jolt on the flat and not when you’re parked on a hill is that the driveline is relaxed on the flat, leaving a little slack for the thump to occur. When parked downhill, gravity has caused the driveline to take up that slack (plus your foot is probably on the brake, preventing the car rocking or moving at all) so the thump can’t occur and, therefore, isn’t felt.

Question 3

Are there known transmission problems with the 2011 Hyundai iLoad?

Accepted Answer

There doesn't seem to be a huge number of similar complaints to yours, Len, but that's pretty cold comfort. You could have a problem with the transmission itself or the electronics that control it. Either way, it could be that the transmission is stuck in high gear as a form of limp-home mode to avoid doing any further damage to itself. The first step is to have the vehicle scanned for fault codes. Sometimes, a fault will be logged that seems to have nothing to do with the symptom, but can still cause the havoc you're experiencing. Try a transmission specialist first, as it's a fair bet they will have seen this exact problem once or twice before.

Question 4

What is the difference in engine life between the petrol and diesel 2012 Hyundai iLoad?

Accepted Answer

Broadly speaking, diesel engines have longer life expectancies than their petrol equivalents. That's because the typical diesel has to be more strongly engineered to cope with its inherently higher compression ratio and heavier moving parts, which also means it runs slower with less stress. However, the advent of turbocharging and higher diesel engine speeds have also seen some lighter duty diesel engines lose some of that under-stressed longevity, meaning that they're not living as long as some old-school, slow-revving, under-stressed diesels. Modern changes including DPF technology, exhaust gas recirculation (for emissions) and single-rail, high-pressure injection have also contributed to shorter working lifespans in some diesels. In any case, the life you will get out of any engine is directly related to how well it's been serviced and maintained throughout that life. A petrol engine treated to proper servicing will easily outlast a diesel that has been neglected and abused. As for the Hyundai petrol engine in your van, the rule of thumb says you should be aiming for at least 200,000km before spending any meaningful money on repairs. Again, though, this is entirely dependent on regular maintenance.

Question 5

What are the best van options for wheelchair modifications?

Accepted Answer

From the sounds of things, you need a vehicle that can accommodate the wheelchair as an actual seat in the car rather than having the chair folded and stored for the journey. With that in mind, a van or people-mover is by far the best best bet and the news is good, because there are plenty of choices. For a while there, people were converting Ford Falcon station-wagons for this task, but since the Falcon is no longer made, vans have become the new default vehicle to convert. Which makes plenty of sense. There are specialist firms around that will carry out whatever conversion you require and tailor-make the ramps, lock-down points and grab-rails you need to make it work for you. Switched on companies will sit down with you and discuss your precise requirements and engineer something bespoke if necessary. At the moment, the list of car choices is pretty long and includes the new Hyundai Staria, VW Caddy, LDV G10, VW Caravelle, Renault Kangoo, Renault Trafic, Hyundai iLoad, Mercedes-Benz V-Class, Toyota HiAce and, in case you need something really big, even the Toyota Coaster. Some of these companies are also registered as NDIS suppliers. But don’t rule out a second-hand vehicle, either. There are websites around listing used wheelchair-accessible cars for sale. Some will be ex-taxis, but others can be relatively low-kilometre cars that might just have the exact layout you were looking for.

Question 6

I am looking for a used van... do you have any recommendations?

Accepted Answer

Rather than concentrate on a particular brand, the best advice is to find a vehicle with a full service history and signs that it has lived an easy life. Too often, commercial vehicles like vans are bought by their first owner and used and abused. They’re nearly always purchased with a job in mind, and that job can often wreck them or at least shorten their lives. Sometimes, the down-time associated with proper servicing means that maintenance is skipped, other times the sheer weight of the cargo being carried puts a lot of strain on mechanical components. A van that has been used by, say, a pool chemical company might have been exposed to highly corrosive chemicals every day of its life and could be hiding lots of rust. Even a florist’s van might have every nook and cranny filled with potting mix, waiting to become damp and start the rusting process. Another good idea is to buy a van that has already been converted to a camper. This conversion is not an inexpensive process, so letting the previous owner spend the money is a terrific concept. Keep an eye on the classifieds for a van that has done a tour of duty with a grey nomad or van-lifer, and is now up for sale as the owner moves on to something new.

Question 7

Are there any problems with the diesel engines in the 2017 Hyundai iLoad?

Accepted Answer

Hyundai’s diesel engines are generally regarded as being among the better ones on the market. That’s probably because the South Korean domestic market has been switched on to small capacity diesels for decades and, as a result, Hyundai has been building them just as long. But, like any modern turbo-diesel, the iLoad’s diesel can be prone to a build-up of black gunk in the intake system, a result of diesel soot and oil mist mixing as part of the vehicle’s own emissions-control systems. The other problem that has cropped up a few times now is a failed turbocharger unit. Generally, this has been the result of a blocked oilway that feeds lubricating oil to the turbo’s bearing. This is a narrow oilway and any sludge in the engine can block it and starve the turbo of its oil. Which is when the turbo itself fails. That’s far more likely to happen in a vehicle that has not had the correct maintenance with regards oil changes. So check the service handbook before handing over the cash and only buy a second-hand iLoad with a full and correct service history.

Question 8

What is the best van for a camper conversion for less than $15000?

Accepted Answer

The Hyundai iLoad/iMax is a great buy for what you intend to use it for, as they're big, robust and roomy boxes on wheels. Not especially quiet, refined or car-like, but well suited to a camper conversion. However, you must ensure that the example you are looking at has a full and regular service record. This is because the well-known diesel engine and turbo failures are connected with lapsed servicing. It seems oil sludge builds up, thus starving the engine and turbo of sufficient lubrication. But here's the tricky bit. Hyundai recommended that all scheduled servicing was carried out every 15,000km, when actually 10,000km maximum was closer to the truth for vans that were driven regularly or had a hard life. Which is most of them. So, you need to buy on condition as well as service history, to ensure you get the promised long-life out of the iLoad/iMax. If that's the case, you can expect to hit 300,000km without any major issues. Just get that oil changed regularly!

Question 9

Hyundai iLoad 2009: Can I replace the engine?

Accepted Answer

I don't believe there is one, but try the Castlemaine Rod Shop (03 5472 2853) as they do a lot of that sort of thing and might have something they could help you with. If they don’t you could have the conversion done by a Vicroads accredited engineer, but it would an expensive exercise and I would think it would be more economical to buy a replacement diesel engine for your van.

Question 10

Hyundai iLoad: How reliable is the engine and turbo?

Accepted Answer

The key to getting a decent run out of the iLoad is to change the oil more frequently. Change it every 5000 km. But if you’re not sure about its reliability certainly walk away. The HiAce is probably the best bet for you, but you could consider a VW Transporter, Mercedes-Benz Vito or Renault Trafic.

Hyundai ILOAD 2009 Problems

The gearbox in my 2009 Hyundai iLoad clunks going into gear

Hyundai iLoad 2009: Can I replace the engine?

Hyundai iLoad 2009: Turbo actuator fault

Hyundai iLoad 2009: Diesel filter clogged

Used Hyundai iLoad review: 2008-2009

Search from Over 8,000 questions Over 8,000 questions answered by CarsGuide

Complete Guide to Hyundai
Iload

Related cars for sale

cars

guide

Hyundai ILOAD 2009 Problems

The gearbox in my 2009 Hyundai iLoad clunks going into gear

Hyundai iLoad 2009: Can I replace the engine?

Hyundai iLoad 2009: Turbo actuator fault

Hyundai iLoad 2009: Diesel filter clogged

Used Hyundai iLoad review: 2008-2009

Search from Over 8,000 questions Over 8,000 questions answered by CarsGuide

Complete Guide to HyundaiIload

Related cars for sale

cars

guide

Complete Guide to Hyundai
Iload