Mitsubishi Pajero Problems

It’s a bit hard to go past an older Holden Commodore or Ford Falcon for this brief. That said, your towing requirement means you’d be best looking at something like an AU (1998 to 2003) Falcon Ute (assuming you only need to move one other person).

These are strong, simple cars that any mechanic can deal with and parts are plentiful and relatively cheap. There are other options (older Japanese dual-cabs) but nothing really gets close to the Aussie stuff for durability and running costs. An elderly Nissan Navara, for instance, might do the job but is likely to become fragile as it ages. A two-wheel-drive Toyota HiLux is another possibility, but you’d probably be right at the limit of your towing capacity with one of those. The Falcon ute, meanwhile, can legally tow 2300kg. It’s not glamorous or sexy, but it’ll do the job and stay on target price-wise.

The other obvious contender would be an early Mitsubishi Pajero with a V6 engine. These had a towing capacity of 2500kg and are around now for very little money, certainly within your budget. They also double as a very handy off-roader should you wish.

Perhaps the clue here is that the problem only occurs when the fuel level reaches one-quarter or less. That suggests that there’s a problem with the fuel pick-up in the bottom section of the tank. Typically, this will involve a split in the fuel pick-up line.

When the tank is full of fuel, fuel covers the split, allowing the pump to pick up fuel normally. As the level falls, the split is exposed and suddenly the pump is sucking air instead of fuel.

Alternatively, your problem could be bleed-back of the fuel pressure when the car is parked, but that would potentially affect things regardless of how much fuel was in the tank at the time. Unless the bleed-back is being caused by the split we’re talking about, in which case you’re back to square one. Either way, it would be wise to check pump pressure and delivery rate (litres per minute) to see that the pump itself is working properly and at correct capacity. Don’t rule out something like a blocked fuel filter, either, which can seriously reduce the flow of the fuel to the engine; critical in any cold-start situation.

You really have two ways to go here. The fact that you want to go off-road in the best/worst conditions this country has to offer means an SUV or cross-over just isn’t going to cut it. With that in mind, you’re looking at either a dual-cab ute or a conventional four-wheel-drive wagon.

In the ute world, there’s plenty of choice within your budget, but you need to be careful that the vehicle in question hasn’t been worked to death by a tradie towing a bobcat Monday to Friday. The popularity of these vehicles, meanwhile, means that there’s lots of choice when it comes to aftermarket bits and pieces to complete your dream vehicle.

The other route – a conventional wagon-style 4X4 – also places a lot of choice within your budget. The Toyota LandCruiser Prado would be a good choice, as would something like a Mitsubishi Pajero which has always represented good value for money both brand-new and second-hand. You could also look at Nissan Patrols which also give you plenty of car for the money and, if you shop carefully, you could find a really nice LandCruiser 80 Series, reckoned by some to be the absolute pinnacle of off-road wagons, even though they’re getting on a bit now. There’s great aftermarket and service support for all these options, so it will come down to your personal preferences.

The Mitsubishi Pajero is actually regarded as a very reliable vehicle, so your experience is not typical. There are several potential causes for this, but the thing I’d check first would be the air filter. Is it possible this was overlooked during the recent service? A blocked or dirty air filter will certainly make an engine blow smoke and operate poorly.

I’m assuming your vehicle is a diesel, so it would be worth checking the suction-control valve on the back of the fuel pump, too. Also, a stuck injector that is pouring fuel into the engine can also potentially create these symptoms. I’ve also heard of the Pajero diesel suffering from a build-up of black gunk inside the intake system that can also cause symptoms like the ones you’ve described.

A car with a little extra ground clearance is great for camping as it often allows you to get a little farther away from the masses in their caravans who tend to huddle around the shower block at bush campsites.

The Subaru Outback is a good, solid choice and if you can find an independent workshop to service it, you’ll avoid the cost of dealership prices. And you’re right, the all-wheel-drive would be great for gravel roads. Another vehicle to look at would be a late-model Ford territory diesel which is big and clever inside and has the option of all-wheel-drive. The diesel engine is a plus on the bush where that fuel is more readily available (in really remote areas) and gives you more range for big holidays in the mulga.

Don’t rule out things like the Mitsubishi Pajero, either, which won’t be as around-town friendly, but is a proven quantity and is absolutely tremendous off-road. The same goes for a Toyota Prado or Nissan Pathfinder prior to the current model (which is a bit less hard-core adventure).

Engines are amazing things, Renee. Neglected, they can fall to bits in a surprisingly short space of time. But treat them properly with the correct preventative maintenance and you’d be surprised how far they’ll go before they wear out.

What you haven’t told me is whether your vehicle is diesel or petrol powered. That said, both the diesel and petrol engines fitted to this model Pajero are well regarded in the trade and capable of going the distance if, as you claim, the servicing has been by the book. Over the distance you’ve quoted, I’d expect the diesel to have needed possibly a new turbocharger and definitely new fuel-injectors, while the petrol V6 can cover this distance without any major work.

But while the engine might, indeed, have lots of life left in it, what about all the other components? The brake rotors, shock absorbers, transmission and many other intrinsic parts of the vehicle wear out, too. So, just because the engine is fit and healthy, doesn’t mean the rest of the car will be so tip-top and ready for another 300,000km.

The Mitsubishi Pajero is one of the longest running models ever, and was first seen in 2006 in much the same form as today’s version. With that in mind, the vehicle is very much a known quantity and the trade regards the mechanical package highly.

As with any off-road oriented machine, the major thing to check is how the vehicle has been used (and abused) in the past. If it’s highly accessorised with winches, mud tyres, bash plates and lifted suspension, you can be fairly sure it’s had a tough life.

As the vehicle in question approaches 100,000km, you’ll be up for a new timing belt, as that’s the recommended change interval (some say 90,000km). While you’re in there, the advice is to change the water pump and the various tensioners and pulleys at the same time. It’s a lot easier to do it all in one hit than have to open the front of the engine a second time.

On the recall front, the big one to watch is the Takata air-bag fiasco which did affect this model.

I don’t know of any insurance companies that will pay out an increased amount because of recent repairs. The presumption would have been that your car was worth the $6000 agreed-value amount only if it was in good working order and not in a damaged state. Following that presumption is the fact that, if it needed $1500 spent on it to bring it back to that condition, that’s simply a wear and tear cost that is not the insurer’s problem. It’s a cruel world, no?

As for the payout figure including (or not) the registration refund, I’d imagine that would be up to the insurer and would be included in the dreaded fine-print. From what I can gather, this is a pretty common inclusion on most policy wordings, and many insurers will adjust the payout down to include the policy excess (if, unlike your case, Tracey, you were at fault) and the unused portion of the CTP insurance and registration. But get this: Some insurers will even deduct the costs of the rest of the year’s insurance premium from your payout, even if you were paying the premium monthly! Never gloss over the fine print.