Suzuki Swift Problems

Replacing random parts to fix a problem is a great way to tear up dollars and time. It’s also pretty frustrating when the problem doesn’t go away. The first thing to do is to have the car electronically scanned to see if the car’s own computer can point you towards the cause of the problem.

It may be as simple as the car needs a tune up and a new set of spark plugs, but you won’t know until it’s been properly diagnosed. This is not a complex car, so any good workshop should be able to sort it for you. The other problem, of course, is that the issue is intermittent, so it may take the workshop some time to be able to make the problem appear. Patience is the key here, not throwing a load of new parts at it.

In modern cars with bonded windscreen, the glass is actually a structural part of the car. Therefore, if the car cops a big enough impact (say, hitting a pothole at speed) it’s conceivable that the stress passing through the whole car could cause a crack in the glass. Stress cracks in windscreens are usually fairly straight and will emanate from the edge of the glass.

The other way to crack a windscreen is to subject it to extremes of temperature. Pouring boiling water over an icy windscreen on a cold morning is a great way to crack the glass, but high interior temperatures in hot weather can also cause cracking in extreme cases.

Suzuki, like just about every other car-maker has a list of things that aren’t covered by warranty, including batteries, tyre, brakes pads and, as you’ve discovered, glass.

You could be looking at any number of causes for this, and some of them herald the demise of your engine. Get a mechanic to check the car out. They will probably do a compression test, a leak-down test and have a close listen to the engine both at idle and under load.

If the cracking sound is a backfire or misfire, you may have an ignition problem. But the smoke is a bit more involved as it depends on the colour of the smoke. Black smoke suggests poor fuelling, but blue or grey smoke often means internal engine wear.

It is indeed a dangerous situation, especially if you’re trying to pull into fast-moving traffic when the engine suddenly cuts out. Frankly, there are literally hundreds of causes for this, so the best advice is to go back to basics and try to find anything wrong with the fuel or ignition system. An electronic scan of the car (if it hasn‘t already been done) is a good idea, too, as it might pin-point the problem area.

You could be looking at something as simple as a poor earth connection or a blocked fuel filter. That the car runs properly in the meantime, suggests that it’s an intermittent fuel or electrical problem rather than an inherent mechanical failure.

There are a few things to check here. The first is that even though the battery has been recharged, has it been load tested? This time of year is very hard on batteries and even though it may seem to be holding a charge, when you actually put a load on it via the starter motor, it can go weak at the knees and will not spin the engine over.

The clicking you can hear is probably the starter motor’s relay which controls the power to the starter. But what about the starter motor itself? Has this been tested for correct operation. Sometimes the problem can also be what’s called the throw-out mechanism which is a solenoid that forces the starter motor’s teeth to mesh with the engine’s flywheel teeth and, therefore, turn things over.

Perhaps an auto electrician is the best place to start. Their first job will be to test a range of things and rule out possible causes one by one.

Spark plugs can foul with oil or with fuel if the mixture is incorrect or the fuel is old and stale. If it’s fuel that’s the problem you need to either fix the problem that is throwing the air-fuel ratio out of whack or replace the fuel if its old (and modern ULP doesn’t have a huge shelf life). Experience has also shown that once a spark plug has fouled because of old ULP, no amount of cleaning will bring that plug back to life.

If it’s oil that’s fouling the plug, it’s probably because of blow-by from worn piston rings or valve-stem seals. If that’s the case, the oil level n the dipstick will be falling over time and you may even see evidence of blue-grey smoke from the tailpipe. Without knowing how many kilometres this engine has covered and how it’s been serviced, it’s very difficult to suggest what the cause might be.

You can google this request and come up with a few websites that say they offer a free workshop manual, as well as a few less sites that actually do offer a downloadable (usually as a PDF) workshop and service manual. The content may or may not be factory content, however, so keep that in mind.

Many of these websites are sneakily constructed to make you click on a link that is nothing to do with the manual allegedly being offered, and you can wind up going down some long advertising rabbit-holes that will ultimately take you nowhere.

Possibly a better bet is to find a reputable online book retailer which offers the workshop manual you're looking for. In many cases, this will still be a PDF meaning you need a computer to access it. Experience suggests that a hard-copy workshop manual is a much better idea as it can be taken with you to the driveway or workshop and referred to quickly and easily part-way through a particular job. And given the modest price of such books, it's a small percentage of the cost of a repair you can now do yourself instead of paying somebody else to tackle.

Being a Japanese car (Japan drives on the left as we do) the indicator stalk is on the right of the steering column. Most drivers find this is a more natural place to have them, and this is probably down to muscle memory as generations of Australian cars had the indicators to the right of the column as well.

That said, many European cars place the indicators to the left of the column, but it's surprising how quickly you'll adapt to that. Many Australians had their first taste of indicators-on-the-left in early air-cooled Volkswagens. This was more of an issue when cars had manual transmissions and you needed your left hand to change gears while hitting the indicators with your right hand.

The first thing to know is that if the car is not presented for delivery in the condition in which bit was described in the contract of sale, you don’t have to accept it. Without knowing the exact circumstances, it sounds as though the car may have ben used as the dealership’s demonstrator model. If that’s the case, it should be sold as such and at a discount to your fiancée.

Check the date of first registration. That might give you a clue as to how long it’s actually been driven on the road. You would expect a handful of kilometres to be added as the car is sent for pre-delivery and detailing, but 800km seems a bit sharp. If you go ahead, make sure you ask whether the warranty will start from the day you take delivery or will be back-dated to the date of first registration.